Suzuki dt4 outboard manual#
This service manual is specifically written for the do-it-yourselfer as well as the experienced mechanic. Hundreds of pages allow you to print it out in its entirety or just the pages you need!! Its important to buy the right repair manual for your Suzuki DT4 DT-4 1988 1989 1990 1991 1992 1993 1994 1995 1996 1997 1998.
Suzuki dt4 outboard crack#
carboning Propeller, shear Check for damage Check for damage Grease propeller pin and cotter pin shaft Choke Check for proper Check for proper operation operation Clean and check for Fuel tank crack and fuel leak- age (Usually check) Fuel strainer Check for clean- liness Check for fuel Check for fuel Fuel hoses leakage leakage and hose cracking Lubrication hose Check for crack Check for crack and breakage and breakage Check impeller Replace if worn Water pump and casing for out wear Handle Grease Adjust pre-load Grease Clutch lever Grease Starter rope Check for tear and wear Tilt Adjust pre-load.(0.024 -0.028 in.) Wire harness Check connec- Check connec- tions for tightness tions for tightness Ignition timing Check and adjust Carburetor Check and adjust Check and adjust Gear oil Change Change Hypoid gear oil, SAE # 90, 190 ml Piston, cylinder De-carbon Renew gasket when and head de This outboard motor user should be advised to go by the following schedule, which is based on the con- cept of systematic care: Item Servicing intervals Remarks 1st 10 hrs Every 50 hrs Every 100 hrs Bolts and nuts Retighten Retighten Spark plug Clean and adjust BP6HS, 0.6- 0.7 mm plug gap. GENERAL INFORMATION 7 MAINTENANCE, INSPECTION AND SERVICING Keeping this outboard motor in the best operable condition at all times involves neither cumbersome measures nor costly expert attention: just carry out simple ordinary services in a systematic manner at regular intervals. 50 parts of gasoline to 1 part of SUZUKI CCI oil or BIA certified lubricant or * 30 parts of gasoline to 1 part of other out- board motor oil.20 parts of gasoline to 1 part of other out- board motor oi I.
30 parts of gasoline to 1 part of SUZUKI CCI oil orB lA certified lubricant or.
I I 5 10- I I Thereafter © During the first 5 hours: Therefore, we hope that you will guide our users as instructed below. the first 5 hours, operate the engine with a partial throttle (within 3/4 throttle opening). ®During initial 5 minutes, operate the engine at trolling speeds. Adhere to the following treatment referring to the above table. This initial 5 hours of operation is the critical period.
1-1 Breaking-in period is initial 5 hours.
0 kommentar(er)
